Daily, weekly, monthly, quarterly, and annual inspection checklists for every system in the container.
Perform these checks every operating day, before startup. Initial each item as you verify it.
| System | Check | Done |
|---|---|---|
| Generator | Check engine oil level — add if low | ☐ |
| Generator | Check coolant level — add if low | ☐ |
| Generator | Check fuel level — refill if low | ☐ |
| Generator | Walk around for leaks (oil, coolant, fuel) | ☐ |
| Generator | Verify DSE7310 has no active alarms | ☐ |
| Compressor | Check compressor oil level — add if low | ☐ |
| Compressor | Drain receiver tank condensate | ☐ |
| Compressor | Inspect for air leaks (listen while running) | ☐ |
| Air Dryer | Verify drain valve is functioning | ☐ |
| Air Dryer | Check and drain coalescing filter bowl | ☐ |
| Transfer Pumps | Verify both pumps cycle and supply material | ☐ |
| Transfer Pumps | Check for leaks at drum bungs and pump outlets | ☐ |
| Reactors | Verify A and B inlet filters are clean | ☐ |
| Reactors | Check for material leaks at all fittings | ☐ |
| Reactors | Verify heaters reach setpoint | ☐ |
| Hoses | Inspect all hoses for damage, kinks, abrasion | ☐ |
| Guns | Verify mix modules are installed and not worn | ☐ |
| Guns | Check gun o-rings and seals | ☐ |
| Drum Heaters | Verify heaters are on and at setpoint | ☐ |
| Drum Heaters | Verify drums are secured with straps | ☐ |
| Container | Verify fire extinguisher present and charged | ☐ |
| Container | Check for spills — clean any found | ☐ |
| Container | Verify all E-stops are in released position | ☐ |
| Container | Verify ventilation is adequate | ☐ |